Portable 300TPH Astec Six Pack Coater Drum Plant

• Astec Six Pack Coater Plant
  • This Astec 300 TPH six pack single shaft coater plant has partial portable characteristics
  • It is a semi complete and is in well above average condition
  • Astec long ago set the standard for the highest quality equipment
• 4 Bin Cold Feed System
  • The four-bin system is portable
  • The bins are 9’ x 12’ with 8’ long x 24” feeders driven by 3 HP DC motors with reducers
  • Each bin has a small scalping screen under the variable speed feeders
  • Radial adjustable gates allow for even flow of materials
  • There is a built-in bulkhead and bolt on bin extenders
  • The collector conveyor runs past the end of the bins ~20 to feed the screen deck
• Drum Dryer
  • A 30” slinger belt introduces the materials into the drum mixer
  • The drum mixer coater drum is 7’ x 42’ long
  • A Hauck Star Jet SJO 360 burner with turbo blower supplies the heat
  • Set up on diesel
  • The drum is driven by a 4 x 30 HP motor arrangement to four trunnions
  • The recycle collar is mounted ~ one third of the way down the dryer
  • The material feeds through the dryer to the single shaft coater pugmill
• Baghouse
  • The Astec portable baghouse is a direct pulse design
  • The bags are 8’ long and 5” in diameter
  • All bags and Goyen pulse valves are accessible through the top of the house
  • A 200 HP motor with fan, remote damper, and EPA stack are included
  • The rotary screw air compressor and air holding tank are included
• Liquid Asphalt Tank
  • The portable liquid asphalt tank is split with 10-20,000 Gallon coiled liquid asphalt
  • The liquid asphalt pump is located on the rear platform on the tail
  • There is an independent Meeker 1 MBTU hot oil heater and a separate fuel oil preheater along with an external 10,000 Gallon vertical fuel tank
  • All plumbing and wiring are included
• Control House
  • The 10’ x 12’ control house is mounted on Conex box
  • There are no controls except the Hauck burner control
  • The controls were proprietary to the company and could not go with the plant
• Lime(Dust) System
  • 400 bbl. Lime(dust) silo (Pressurized) with a weigh pod and 14” vain feeder to meter the duct in the pneumatic blower to the drum
• Other Equipment Included
  • A Conex box is included with some parts
  • Note: Even though the plant is not totally portable, the portable pieces have all their tires and rims
  • There have been numerous upgrades done in the last 5 years to include, but not limited to:
    • Baghouse bags in 2015, new liners and fights in the drum 2014, and rebuilt vain feeder 2016.
    • Most of the S.O. Cable has been replaced with heavier more permanent wire
  • This plant is available only because a much higher production plant is replacing it
  • It is in very good running order, ran fine at shut down
  • Plant runs consistently at 250 TPH using 25% recycle
  • Note: Road readiness on the portable part of the plant must be checked prior to transportation
  • Plant still erected and must be off site ASAP
• Located in PA

Call Today 518-218-7676